Zum Hauptinhalt wechseln

基本的なLED懐中電灯のDIYはんだ付けキットの組み立て

Englisch
Japanisch
Schritt 9
Basic LED Flashlight DIY Soldering Kit Assembly, Solder the resistor: Schritt 0, Bild 1 von 3 Basic LED Flashlight DIY Soldering Kit Assembly, Solder the resistor: Schritt 0, Bild 2 von 3 Basic LED Flashlight DIY Soldering Kit Assembly, Solder the resistor: Schritt 0, Bild 3 von 3
Solder the resistor
  • In this step, you're going to heat the solder pad and the resistor's lead so that they'll readily melt the solder wire.

  • Press the tip against the circuit board's solder pad and the resistor's lead for a few seconds to heat them both. Angle the tip so it has maximum contact with the pad and lead.

  • If you heat the circuit board continuously for more than 10 seconds, the excessive heat may damage the solder pad or resistor.

  • Feed the solder wire into the heated area until there's a concave pool ("mini volcano") of solder surrounding the lead.

  • Don't feed the solder directly onto the tip as it won't flow properly into the pad and lead, causing a weak connection.

  • The volcano should form within a few seconds. If the solder doesn't adhere to the pad, apply flux to the pad or increase the temperature.

  • Remove the solder wire first, then remove the soldering iron from the pad.

  • Repeat this process for the second resistor lead.

このステップでは、はんだパッドと抵抗器のリード線を熱して、はんだワイヤーを容易に溶かすようにします。

こて先を回路基板のはんだパッドと抵抗器のリード線に数秒間押し当てて、両方を加熱します。こて先をパッドとリード線に最大限接触するように角度を調整します。

10秒以上連続して回路基板を加熱すると、過剰な熱により半田パッドまたは抵抗器が損傷する恐れがあります。

リードの周囲に半田のくぼみ(「ミニ火山」)ができるまで、加熱した部分に半田ワイヤを挿入します。

はんだを直接こて先に供給すると、パッドとリード間にはんだが適切に流れず、接続が弱くなるため、行わないでください。

数秒以内に「ミニ火山」が形成されるはずです。はんだがパッドに付着しない場合は、フラックスをパッドに塗布するか、温度を上げてください。

まずはんだを吸い取り、その後はんだごてをパッドから離します。

2つ目の抵抗器にも同じ手順を繰り返します。

Deine Beiträge sind lizenziert unter der Open-Source Creative Commons Lizenz.